Transient Voltage Suppressors Diodes Surface Mount - 600W > SMBJ5.0~440CA Series The SMBJ series is designed specifically to protect sensitive electronic equipment from voltage transients induced by lightning and other transient voltage events. Features • Halogen-free • Rohs compliant • Typical maximum temperature coefficient ΔVBR = 0.1% x SMB/DO-214AA unit:inch(mm) VBR@25°C x ΔT • Glass passivated Chip junction in DO-214AA package • 600W peak pulse capadility at 10×1000μs waveform, repetition rate(duty cycles):0.01% • Fast response time:typically less than 1.0ps from 0 Volts to BV min • Excellent clamping capability • Low incremental surge resistance • Typical IR less than 5μA above 12V • High temperature soldering guaranteed: 260°C/40 seconds / 0.375”,(9.5mm) lead length, 5lbs., (2.3kg) tension • Plastic package has underwriters laboratory flammability classification 94v-0 Applications TVS devices are ideal for the protection of I/O interfaces, VCC bus and other vulnerable circuits used in telecom,computer, industrial and consumer electronic applications. Maximum Ratings And Characteristics (TA=25°C unless otherwise noted) Value Symbol Rating Units Peak Pulse Power Dissipation by 10x1000μs test waveform (Fig.1)(Note 1) Steady State Power Dissipation on inifinite heat sink at TL=75ºC (Fig. 5) Peak Forward Surge Current, 8.3ms Single Half Sine Wave Unidirectional only (Note 2) Maximum Instantaneous Forward Voltage at 25A for Unidirectional only (Note 3) Operating junction and Storage Temperature Range. Typical Thermal Resistance Junction to Lead PPPM PD IFSM VF TJ,TSTG RuJL 600 5 100 3.5/5.0 -55 to 150 20 Watts Watts Amps V °C °C/W Typical Thermal Resistance Junction to Ambient Notes: 1. Non-repetitive current pulse , per Fig. 3 and derated above TA = 25°C per Fig. 2. 2. Mounted on copper pad area of 0.2x0.2” (5.0 x 5.0mm) to each terminal. 3. Measured on 8.3ms single half sine wave or equivalent square wave for unidirectional device only, duty cycle=4 per minute maximum. 4. VF<3.5V for VBR < 200V and VF<5.0V for VBR > 201V. °C/W RuJA 100 All data are subject to changes,Please check our data sheets at www ruilon com for updates. ©2012 RuiLongYuan,Inc. TVS 01 

Electriacl Characteristics Type Number Device Marking Code Reverse Stand-Off Voltage Breakdown Voltage@IT Test Current Maximum Clamping Voltage@IPP Peak Pulse Current Reverse Leakage @VRWM (UNI) SMBJ3.3A SMBJ5.0A SMBJ6.0A SMBJ6.5A SMBJ7.0A SMBJ7.5A SMBJ8.0A SMBJ8.5A SMBJ9.0A SMBJ10A SMBJ11A SMBJ12A SMBJ13A SMBJ14A SMBJ15A SMBJ16A SMBJ17A SMBJ18A SMBJ20A SMBJ22A SMBJ24A SMBJ26A SMBJ28A SMBJ30A SMBJ33A SMBJ36A SMBJ40A SMBJ43A SMBJ45A SMBJ48A SMBJ51A SMBJ54A SMBJ58A SMBJ60A SMBJ64A SMBJ70A SMBJ75A SMBJ78A SMBJ85A SMBJ90A SMBJ100A SMBJ110A SMBJ120A SMBJ130A SMBJ150A SMBJ160A SMBJ170A SMBJ180A SMBJ190A SMBJ200A SMBJ210A SMBJ220A SMBJ250A SMBJ300A SMBJ350A SMBJ400A SMBJ440A (BI) * SMBJ5.0CA SMBJ6.0CA SMBJ6.5CA SMBJ7.0CA SMBJ7.5CA SMBJ8.0CA SMBJ8.5CA SMBJ9.0CA SMBJ10CA SMBJ11CA SMBJ12CA SMBJ13CA SMBJ14CA SMBJ15CA SMBJ16CA SMBJ17CA SMBJ18CA SMBJ20CA SMBJ22CA SMBJ24CA SMBJ26CA SMBJ28CA SMBJ30CA SMBJ33CA SMBJ36CA SMBJ40CA SMBJ43CA SMBJ45CA SMBJ48CA SMBJ51CA SMBJ54CA SMBJ58CA SMBJ60CA SMBJ64CA SMBJ70CA SMBJ75CA SMBJ78CA SMBJ85CA SMBJ90CA SMBJ100CA SMBJ110CA SMBJ120CA SMBJ130CA SMBJ150CA SMBJ160CA SMBJ170CA SMBJ180CA SMBJ190CA SMBJ200CA SMBJ210CA SMBJ220CA SMBJ250CA SMBJ300CA SMBJ350CA SMBJ400CA SMBJ440CA UNI KC KE KG KK KM KP KR KT KV KX KZ LE LG LK LM LP LR LT LV LX LZ ME MG MK MM MP MR MT MV MX MZ NE NG NK NM NP NR NT NV NX NZ PE PG PK PM PP PR PT PV PX PZ QE QG QK QM QP QR BI * AE AG AK AM AP AR AT AV AX AZ BE BG BK BM BP BR BT BV BX BZ CE CG CK CM CP CR CT CV CX CZ DE DG DK DM DP DR DT DV DX DZ EE EG EK EM EP ER ET EV EX EZ FE FG FK FM FP FR VRWM(V) VBR MIN.(V) VBR MAX.(V) IT(mA) 3.3 5.0 6.0 6.5 7.0 7.5 8.0 8.5 9.0 10.0 11.0 12.0 13.0 14.0 15.0 16.0 17.0 18.0 20.0 22.0 24.0 26.0 28.0 30.0 33.0 36.0 40.0 43.0 45.0 48.0 51.0 54.0 58.0 60.0 64.0 70.0 75.0 78.0 85.0 90.0 100.0 110.0 120.0 130.0 150.0 160.0 170.0 180.0 190.0 200.0 210.0 220.0 250.0 300.0 350.0 400.0 440.0 4.10 6.40 6.67 7.22 7.78 8.33 8.89 9.44 10.00 11.10 12.20 13.30 14.40 15.60 16.70 17.80 18.90 20.00 22.20 24.40 26.70 28.90 31.10 33.30 36.70 40.00 44.40 47.80 50.00 53.30 56.70 60.00 64.40 66.70 71.10 77.80 83.30 86.70 94.40 100.00 111.00 122.00 133.00 144.00 167.00 178.00 189.00 201.00 209.00 220.00 231.00 242.00 279.00 335.00 391.00 447.00 492.00 4.60 7.25 7.67 8.30 8.95 9.58 10.23 10.82 11.50 12.80 14.00 15.30 16.50 17.90 19.20 20.50 21.70 23.30 25.50 28.00 30.70 33.20 35.80 38.30 42.20 46.00 51.10 54.90 57.50 61.30 65.20 69.00 74.10 76.70 81.80 89.50 95.80 99.70 108.20 115.50 128.00 140.50 153.00 165.50 192.60 197.00 209.00 222.00 243.20 247.00 268.80 281.60 309.00 371.00 432.00 494.00 543.00 1 10 10 10 10 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 VC(V) 7.3 9.2 10.3 11.2 12.0 12.9 13.6 14.4 15.4 17.0 18.2 19.9 21.5 23.2 24.4 26.0 27.6 29.2 32.4 35.5 38.9 42.1 45.4 48.4 53.3 58.1 64.5 69.4 72.7 77.4 82.4 87.1 93.6 96.8 103.0 113.0 121.0 126.0 137.0 146.0 162.0 177.0 193.0 209.0 243.0 259.0 275.0 292.0 308.0 324.0 340.0 356.0 405.0 486.0 567.0 648.0 713.0 IPP(A) 50.0 65.2 58.3 53.6 50.0 46.6 44.1 41.7 39.0 35.3 33.0 30.2 27.9 25.8 24.6 23.1 21.7 20.5 18.5 16.9 15.2 14.2 13.2 12.4 11.3 10.3 9.3 8.6 8.3 7.7 7.3 6.9 6.4 6.2 5.8 5.3 4.9 4.7 4.4 4.1 3.7 3.4 3.1 2.9 2.5 2.3 2.2 2.1 2.0 1.9 1.8 1.7 1.5 1.3 1.1 0.9 0.9 IR(µA) 200 800 800 500 200 100 50 20 10 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 5.0 TVS 02 All data are subject to changes,Please check our data sheets at www ruilon com for updates. ©2012 RuiLongYuan,Inc. 

Ratings and Characteristic Curves (TA=25℃ unless otherwise noted) Figure 1 - Peak Pulse Power Rating A Figure 2 - Pulse Derating Curve ) W k ( r e w o P e s u P k a e P - M P P P l 100 10 1 0.2x0.2" (5.0x5.0mm) Copper Pad Area 0.1 0.000001 0.00001 td-Pulse Width (sec.) 0.0001 0.001 ) P P I ( t n e r r u C r o ) P P P % e g a t n e c r e P n i g n i t a r e D ( r e w o P e s u P k a e P l 100 80 60 40 20 0 0 25 50 75 125 TA - Ambient Temperature (ºC) 100 150 175 Figure 3 - Pulse Waveform Figure 4 - Typical Junction Capacitance 150 100 50 M S R I % , t n e r r u C e s u P k a e P l - M P P I td 0 0 tr=10µsec TJ=25°C as the point where the peak current decays to 5 0% of IPPM Peak Value IPPM Half Value IPPM ( ) IPPM 2 10/1000µsec. Waveform 1.0 2.0 3.0 4.0 t-Time (ms) 10000 1000 100 10 ) F p ( j C Bi-directional V=0V Uni-directional V=0V Uni-directional @VR Bi-directional @VR Tj=25C f=1.0MHz Vsig=50mVp-p 1 1.0 10.0 100.0 1000.0 VBR - Reverse Breakdown Voltage (V) Figure 5 - Steady State Power Dissipation Derating Curve Figure 6 - Maximum Non-Repetitive Peak Forward Surge Current Uni-Directional Only n o i t i a p s s D i r e w o P e t a t S y d a e t S , ) ( V A M P ) W ( 6 5 4 3 2 1 0 0 25 50 75 100 125 150 175 TA - Ambient Temperature (ºC) ) A ( t n e r r u C e g r u S d r a w r o F k a e P - M S F I 120 100 80 60 40 20 0 1 01 001 Number of Cycles at 60 Hz All data are subject to changes,Please check our data sheets at www ruilon com for updates. ©2012 RuiLongYuan,Inc. TVS 03 

Soldering Parameters Pre Heat - Temperature Min (T s(min)) - Temperature Max (T s(max)) - Time (min to max) (t s) 150°C 200°C Average ramp up rate (Liquidus Temp (TL) to peak TS(max) to TL - Ramp-up Rate - Temperature (T L) (Liquidus) - Time (min to max) (t s) Peak Temperature (T P) Time within 5°C of actual peak Temperature (t p) Ramp-down Rate Time 25°C to peak Temperature (T P) Do not exceed 3°C/second max 3°C/second max 217°C 260+0/-5 °C 6°C/second max 8 minutes Max. 280°C TP TL Ts(max) Ts(min) ) T ( e r u t a r e p m e T pu-pmaR tp tL enoZ lacitirC TL to TP Ramp-down ts Preheat Time (t) Weight Case Polarity Terminal 0.003 ounce, 0.093 grams JEDEC DO214AA. Molded plastic body over glass passivated junction Color band denotes cathode except Bidirectional Temperature Cycle JESD22-A104 Pressure Cooker JESD 22-A102 High Temp. Storage JESD22-A103 Matte Tin-plated leads, Solderable per JESD22-B102D HTRB Dimensions DO-214AA (SMB J-Bend) Cathode Band C H B F G K L A D E J I Thermal Shock Dimensions A B C D E F G H I J K L JESD22-A108 JESD22-A106 Inches Millimeters Min 0.077 0.160 0.130 0.084 0.030 - 0.205 0.006 0.089 0.085 - 0.085 Max 0.086 0.180 0.155 0.096 0.060 0.008 0.220 0.012 - - 0.107 - Min 1.950 4.060 3.300 2.130 0.760 - 5.210 0.152 2.260 2.160 - 2.160 Max 2.200 4.570 3.940 2.440 1.520 0.203 5.590 0.305 - - 2.740 - TVS 04 All data are subject to changes,Please check our data sheets at www ruilon com for updates. ©2012 RuiLongYuan,Inc. 

Part Numbering System SMBJ XXX C A 5% VOLTAGE TOLERANCE BI-DIRECTIONAL VOLTAGE SERIES Part Marking System Cathode Band X X X Marking Code Packaging Part number Component Package Quantity SMBJxxxXX DO-214AA 500 Packaging Option Tape&reel Packaging EIA STD RS-481 RUILONG.YUAN CO.,LTD Tel: +86- 0755-82908296 Fax: +86- 0755-82908002 Email: jack@ruilon.com Website: http://www.ruilon.com RuiLongYuan Electronics are trademarks. Information furnished is believed to be accurate and reliable. However, users should independently evaluate the suitability of and test each product selected for their own applications. RUILONYUAN Electronics reserves the right to change or update, without notice, any information contained in this publication; to change, without notice, the design, construction, processing, or specification of any product; and to discontinue or limit production or distribution of any product. This publication supersedes and replaces all information previously supplied. Without expressed or written consent by an officer of RUILONYUAN Electronics, RUILONYUAN Electronics does not authorize the use of any of its products as components in nuclear facility applications, aerospace, or in critical life support devices or systems. RUILONYUAN Electronics expressly disclaims all implied warranties regarding the information contained herein, including, but not limited to, any implied warranties of merchantability or fitness for a particular purpose. RUILONYUAN Electronics’ only obligations are those in the RUILONYUAN Electronics Standard Terms and Conditions of Sale and in no case will RUILONYUAN Electronics be liable for any incidental, indirect, or consequential damages. All data are subject to changes,Please check our data sheets at www ruilon com for updates. ©2012 RuiLongYuan,Inc. TVS 05